Highly efficient deaeration and drying of power transformer oils

Relevanta dokument
Highly efficient deaeration and drying of power transformer oils

SKF smörjsystem. SKF/ToolsMomentum Vindkraftsdag Janne Westerlund, SKF Lubrication Competence Centre

CompactAIR Center Ventilation - Filtrering - Uppvärmning CompactAIR Center Ventilation - Filtration - Heating

Företagsnamn: Grundfos Skapad av: Magnus Johansson Tel: +46(0) Datum:

Viktig information för transmittrar med option /A1 Gold-Plated Diaphragm

Isolda Purchase - EDI

CHANGE WITH THE BRAIN IN MIND. Frukostseminarium 11 oktober 2018

HYDRAULIK Rörströmning IV

Dokumentnamn Order and safety regulations for Hässleholms Kretsloppscenter. Godkänd/ansvarig Gunilla Holmberg. Kretsloppscenter

Boiler with heatpump / Värmepumpsberedare

Preschool Kindergarten

Module 6: Integrals and applications

SOLAR LIGHT SOLUTION. Giving you the advantages of sunshine. Ningbo Green Light Energy Technology Co., Ltd.

LUNDS TEKNISKA HÖGSKOLA Institutionen för Elektro- och Informationsteknik

Sammanfattning hydraulik

Transformator konferens Stavanger /4 Sammanställning av kunskapsläget I Vattenfall och utvecklingen I Sverige

SNÄCKVÄXLAR WORM GEARBOXES

Resultat av den utökade första planeringsövningen inför RRC september 2005

Instruction Manual. Svenska, English. Power Bank. Model: PRBN

Agreement EXTRA. Real wage increases, expanded part-time pensions and a low-wage effort in the unions joint agreement demands.

Consumer attitudes regarding durability and labelling

TN LR TT mg/l N b) 2,6-Dimethylphenole

BRUKSANVISNING. Oscilla 910

HYDRAULIK Rörströmning IV

Questionnaire for visa applicants Appendix A

Nya driftförutsättningar för Svensk kärnkraft. Kjell Ringdahl EON Kärnkraft Sverige AB

Installation Instructions

The test can be performed on the following devices. In addition, the required cuvette and the absorption range of the photometer are indicated.

8 < x 1 + x 2 x 3 = 1, x 1 +2x 2 + x 4 = 0, x 1 +2x 3 + x 4 = 2. x 1 2x 12 1A är inverterbar, och bestäm i så fall dess invers.

Klassificering av brister från internaudit

Signatursida följer/signature page follows

The Finite Element Method, FHL064

ARC 32. Tvättställsblandare/Basin Mixer. inr.se

Ett hållbart boende A sustainable living. Mikael Hassel. Handledare/ Supervisor. Examiner. Katarina Lundeberg/Fredric Benesch

Iron VARIO PP mg/l Fe g) 1,10-Phenanthroline

Analys och bedömning av företag och förvaltning. Omtentamen. Ladokkod: SAN023. Tentamen ges för: Namn: (Ifylles av student.

Split- vs ventilationsaggregat

PORTSECURITY IN SÖLVESBORG

Styrteknik: Binära tal, talsystem och koder D3:1

Vätebränsle. Namn: Rasmus Rynell. Klass: TE14A. Datum:

SHP / SHP-T Standard and Basic PLUS


Isometries of the plane

e-sense Organic Grundläggande princip Basic Principle

SVENSK STANDARD SS-ISO :2010/Amd 1:2010

Hur fattar samhället beslut när forskarna är oeniga?

12.6 Heat equation, Wave equation

MCP-16RC, Air Purification

NORDIC GRID DISTURBANCE STATISTICS 2012

Provtagning i vatten. Jens Fölster Inst. För vatten och miljö, SLU

This manual should be saved! EcoFlush Manual

STORSEMINARIET 3. Amplitud. frekvens. frekvens uppgift 9.4 (cylindriskt rör)

The test can be performed on the following devices. In addition, the required cuvette and the absorption range of the photometer are indicated.

Windlass Control Panel v1.0.1

Application for exemption - Ansökan om dispens

balans Serie 7 - The best working position is to be balanced - in the centre of your own gravity! balans 7,45

Svenska()(Bruksanvisning(för(handdukstork()(1400(x(250(mm(

GOLD SD Med styrenhet/with control unit. Fläkt/ Fan. Utan filter/ Without filter. Fläkt/Fan. Fläkt/ Fan. Med filter/ With filter.

Health café. Self help groups. Learning café. Focus on support to people with chronic diseases and their families

KTH MMK JH TENTAMEN I HYDRAULIK OCH PNEUMATIK allmän kurs kl

säkerhetsutrustning / SAFETY EQUIPMENT

Support Manual HoistLocatel Electronic Locks

Rev No. Magnetic gripper 3

SAMMANFATTNING AV SUMMARY OF

Aborter i Sverige 2008 januari juni

Lignin i pulverpannor

BBT057/ BBC057 BBCD057/ BBT057-NL HOLDEN COLORADO 9/2016+ HOLDEN TRAILBLAZER WD & 4WD Models

Säkerhetsfunktioner rstå varandra? Finns behov av att avvika från normal säkerhetsfunktion s vissa betingelser under uppstart, ändringar i processen

LUNDS TEKNISKA HÖGSKOLA Inst. for Elektro- och Informationsteknik. SIGNALBEHANDLING I MULTIMEDIA, ETI265 Inlämningsuppgift 1 (av 2), Task 1 (out of 2)

1. Compute the following matrix: (2 p) 2. Compute the determinant of the following matrix: (2 p)

Riskhantering. med exempel från Siemens

CUSTOMER READERSHIP HARRODS MAGAZINE CUSTOMER OVERVIEW. 63% of Harrods Magazine readers are mostly interested in reading about beauty

Materialplanering och styrning på grundnivå. 7,5 högskolepoäng

Accepterad monteringsanvisning 2016:1. Metris (RSK: ) Metris S (RSK: ) Metris (RSK: )

Module 1: Functions, Limits, Continuity

Klimatpåverkan och de stora osäkerheterna - I Pathways bör CO2-reduktion/mål hanteras inom ett osäkerhetsintervall

INSTALLATION INSTRUCTIONS

Profilinformation Flygteknink 2019, Ingo Staack

GOLD SD Fläkt 2/ Fan 2. Fläkt 1/ Fan 1. Fläkt/ Fan. Utan filter/ Without filter. Fläkt 1/ Fan 1. Fläkt 2/ Fan 2. Med filter/ With filter Filter

Measuring child participation in immunization registries: two national surveys, 2001

The Arctic boundary layer

AquaTeq Sweden AB Radarvägen 12 SE KALMAR. PHONE: +46 (0) INTERNET:

Inkvarteringsstatistik. Göteborg & Co. Februari 2012

Bridging the gap - state-of-the-art testing research, Explanea, and why you should care


Design by Voice. Azzaro

Lösenordsportalen Hosted by UNIT4 For instructions in English, see further down in this document

AIC SWEDEN. Free route airspace operations between DK-SE FAB FRA and NEFAB FRA

Examples on Analog Transmission

INDUKTIV SLINGDETEKTOR INDUCTIVE LOOP DETECTOR


BOW. Art.nr

Discovery FSQ, IAA Utgåva/Edition 11. SE Habo. Klass 2 IAA FSQ-I 26W. 4 mm c c mm N L

Droppställning / IV stand

State Examinations Commission

Ackrediteringens omfattning

IMPORTANT! RETAIN FOR FUTURE REFERENCE PLEASE READ CAREFULLY VIKTIGT! BEHÅLL FÖR FRAMTIDA REFERENS LÄS IGENOM INSTRUKTIONSMANUALEN

JTS snabbstartsguide. Endast för användning av utbildad personal

1. Förpackningsmaskin / Packaging machine

Ringmaster RM3 - RM 5 RM3 RM 4 RM 5

Transkript:

INDUSTRY Highly efficient deaeration and drying of power transformer oils C.C.Jensen A/S * Løvholmen 13 * DK-5700 Svendborg * Denmark Phone: +45 63 21 20 14 * Fax: +45 62 22 46 15 E-mail: filter@cjc.dk * Homepage: www.cjc.dk

C.C.JENSEN A/S Vacuum Filter Unit January 2001 Continuous de-gasing of transformers The ageing speed of the cellulose isolation material is what determines the length of the life of a transformer. The ageing speed is affected by three main factors: 1. The presence of oxygen. Ageing is caused by the oxidation process and thus depending on the accessability of oxygen. Oxygen is introduced into the transformer through the venting pipe of the expansion reservoir. 2. The presence of water. Water is one of the end products of cellulose and oil ageing processes and is generated in vast quantities inside transformers. Over 99% of dissolved water in a transformer is bound in the cellulose - which, incidently, is where it harms it the most. 3. The presence of acids. Acids are formed one certain steps of the chain of reactions in the oxidation process of the oil, leading to the end-products CO 2 and water. As the oil is surrounding the cellulose it is inevitable that the cellulose is effected by the acids formed in the oil. De-gasing has a positive effect on two of the above factors. Function The CJC TM Vacuum Filtration Unit (de-gasing unit) consists of a vacuum chamber and a filtration insert. A vacuum pump maintains the pressure in the chamber at the lowest possible level. At such low pressure even water turns into a gas and the gas content of the oil is radically reduced during its stay in the vacuum chamber. When the oil is pumped back into the transformer it is absolutely dry. The water content is very close to 0 ppm. The water content of the oil is in equilibrium with the water content of the cellulose. Consequently, when the oil is dried, water will transfer from the cellulose to the oil in order to maintain the equilibrium. The water starts to travel through the cellulose via the oil bordering surface into the oil phase. The travelling speed of the water in the cellulose can only be influenced by one factor: the temperature. That is why all de-gasing (de-hydration) should be performed while the transformer is in operation. The speed of dehydration is affected by the travelling speed of the water through the cellulose - hence, the dehydration must be allowed ample time. The longer time a dehydration process is allowed, the better the result, which is why continuous de-gasing is very advantageous. When the acid contents are reduced the ageing speed of the cellulose and of the oil is reduced accordingly. As an immediate consequence the generation of water is minimized which, in turn, reduces the water content of the cellulose.

C.C.JENSEN A/S Vacuum Filter Unit January 2001 De-gasing removes previously generated water from the cellulose, leading to a further increase of the remaining life length. De-gasing also increases the chargeability of the transformer, enabling higher power outputs of no (negative) consequence to the service life length. Gas Analyses Modern techniques enable new diagnostic methods where gas analyses are performed on the gases withdrawn from the oil. When the de-gasing has been going on sufficiently long, the withdrawn gasses represents the processes that have taken place in the transformer within a relatively short period of time. Hence, a more exact information about the condition of the transformer is achieved. If the gas formation increases drastically a gas-flow-detector can initiate an alarm condition and shut down the transformer. This new type of protective device will have a considerably quicker response than the traditional Bucholz relay, constituting an increased safety level for the owner. Conclusion In short, the continuous de-gasing with a CJC TM Vacuum Filtration Unit enables an extension of the length of remaining service life of a transformer by a factor 2 to 10 (depending on the operating conditions of the transformer). The continuous de-gasing also enables more exact diagnostics of the transformer condition and also a possibility of improved alarm functions. The CJC TM Unit By PLC controlling the operation of the CJC TM Vacuum Filter Unit a very high degree of efficiency is achieved. The vacuum system and the oil discharge circuit are constantly interacting to assure maximum vacuum effect. In order to ensure that solid particles are retained from the fluid, a CJC TM Fine Filter Insert is built into the vaccum unit. The whole unit is designed to require an absolute minmum of maintenance and surveillance. It can be left virtually unattended for months, cleansing, for example the oil on remotely situated transformer units. The capacity of the unit is 200 litres of oil per hour and tests indicate that it will maintain water contents in transformer oils at levels below 10 ppm.

C.C.JENSEN A/S Vacuum Filter Unit January 2001 The below are test results from a transformer unit at the Copenhagen Light and Power Company. The water content oil samples were taken at the bottom of the transformer, whereas the water after vacuum samples were drawn at a sampling point at the outlet of the CJC TM Unit. The water content paper are theoretical values based on an equation presuming a certain balance between water content in the oil and in the paper (isolating material). As long as the vacuum treatment is ongoing this balance is partly disturbed, which is why the figures must not be considered absolute. Date Temp. bottom [Cº] Temp. top [Cº] Water content oil [ppm] Water content paper [%] Water after vacuum [ppm] 30.09.99 20 44 18 2,9 25.10.99 35 53 21 2,6 03.11.99 39 59 24 2,2 12.11.99 33 54 17 2,2 12 22.11.99 30 50 16 2,7 30.11.99 39 55 14 1,9 8 08.12.99 36 56 14 1,9 8 17.12.99 33 52 9 1,7 7 28.12.99 28 52 10 1,7 8 06.01.00 34 54 12 1,8 6 21.01.00 31 50 11 6 27.01.00 36 52 11 7 07.02.00 37 55 10 6 23.02.00 29 50 7 4 23.02.00* 29 50 6 1,5 3 15.12.01 12 18 4 3 08.01.01 27 48 4 4 Analysis by Copenhagen Light & Power *) After calibration of analysis equipment. When looking at the figures above, it must also be considered that the vacuum unit was adjusted and operations tested during the testing period.

M VacuumFiltration Unit Flow & Working Principle Oil Reservoir Vacuum Pump Oil Inlet Fine Filter Element I P Foam Control Vacuum Control Vacuum & Filtration Chamber Foam Sensor Fluid Level Transmitter Return Discharging Oil Pump M Oil Outlet

Västerås PetroleumKemi AB Det OBEROENDE alternativet för industrins analys, service och konsultbehov 2840698 Skallböle T1 Tillverkningsnr: 2840698 Apparatlittera: Skallböle T1 Tillverkare: ASEA Leveransår: 1948 Maskintyp: Transformator Effekt: 15 Högspänning: 130 Lågspänning: 6 Oljevikt: 14800 Totalvikt: Kärnans vikt: Lindningsvikt: Kylsystem: ONAF Expansionssystem: Öppet Lindnings_alt_Lastkopplare: uppg saknas Tillverkare_LK: Uppgift saknas Typbeteckning: TET7509 Isolerolja: Okänd Godkänd av/approved by AR Kund/Purchaser Sydkraft Vattenkraft AB Box 850 857 40 Sundsvall Provnr: 56588 Datum: 2001-03-06 Er Referens/Your Reference Vesa Hartikainen Oljeanalys Ankomstdatum Provtagningsdatum 56588 2001-02-28 2001-02-27 56425 2001-02-12 2001-02-09 56412 2001-02-05 2001-02-02 56394 2001-01-29 2001-01-25 55357 2000-06-14 2000-06-07 Hydrogen H2: <10 <10 14 1 Oxygen O2: 580 1000 4750 16400 Nitrogen N2: 8700 9500 15000 62200 Metan CH4: <1 1 1.3 4.3 Kolmonoxid CO: 39 60 85 530 Koldioxid CO2: 710 1325 >5300 8400 Eten C2H4: 2 6.9 8.6 11 Etan C2H6: 2 3.1 3.7 3.8 Etyn C2H2: 0.05 0.02 <0.01 0.5 Karbonylsulfid COS: 2 6.1 3.3 1.2 Brännbara gaser: 8.34 15.0 27.6 20.8 CH4/H2: 0.20 0.25 0.093 4.3 C2H6/CH4: 2.15 3.1 2.85 0.88 C2H4/C2H6: 1.06 2.23 2.32 2.95 C2H2/C2H4: 0.028 0.003 0.001 0.045 CO2/CO: 18.2 22.1 62.4 15.9 N2/O2: 14.9 9.23 3.16 3.79 Jämviktstryck 0 C: 189 298 999 Jämviktstryck 20 C: 178 270 868 Jämviktstryck 50 C: 169 244 734 Gashalt i olja (NTP): 1.01 1.20 2.52 8.75 Avgasning påbörjad: 01-01-25 01-01-25 Avgasning avslutad: ber 02-01-31 ber 02-01-31 Analyskommentarer: Minskande gashalter. 65 19600 65700 6.3 660 7320 9.7 6.2 0.02 88.2 0.095 0.98 1.56 0.002 11.1 3.35 1980 1852 1733 9.34 mbar mbar mbar %vol@ntp datum datum Adress huvudkontor Bigaråvägen 2 435 43 PIXBO Telefon 031-3381980 Telefax 031-3381774 Adress Laboratoriet Box 189 721 05 Västerås Telefon 021-198017 Telefax 021-181980

Västerås PetroleumKemi AB Det OBEROENDE alternativet för industrins analys, service och konsultbehov 70108 BRT Trf1 Tillverkningsnr: 70108 Apparatlittera: BRT Trf1 Tillverkare: BRUSH Leveransår: 1968 Maskintyp: Transformator Effekt: 20 Högspänning: 30 Lågspänning: 10 Tillverkningsnummer_LK: Oljevikt: 7580 Totalvikt: Kärnans vikt: Lindningsvikt: Kylsystem: ONAF Expansionssystem: Gemensamt Lindnings_alt_Lastkopplare: FBA31333/500 Tillverkare_LK: Fuller Electric Ltd Typbeteckning: Isolerolja: Okänd Godkänd av/approved by Kund/Purchaser Köbenhavns Energie ELB Hulgårdsvej 133 240 00 Köpenhamn Provnr: 56625 Datum: 2001-03-13 Er Referens/Your Reference Thomas M Andersen Gasanalys Ankomstdatum Provtagningsdatum 56625 2001-03-06 2001-03-02 56624 2001-03-06 2001-03-02 56423 2001-02-12 2001-02-09 56422 2001-02-12 2001-02-09 56414 2001-02-02 2001-01-31 Hydrogen H2: <10 <10 15 20 30 Oxygen O2: 1150 720 17000 19200 14300 Nitrogen N2: 5550 5300 47100 48400 44400 Metan CH4: 0.4 0.8 12 3.5 1.7 Kolmonoxid CO: 15 18 125 130 110 Koldioxid CO2: 325 375 4180 4290 4500 Eten C2H4: 0.5 0.7 8.5 7.7 8 Etan C2H6: <0.1 <0.1 0.4 0.4 0.4 Etyn C2H2: 0.4 0.6 7.9 7.3 4.9 Karbonylsulfid COS: 3.1 1.3 7.6 5.4 16 Brännbara gaser: 9.4 8.2 45.8 40.9 43 CH4/H2: 0.05 0.13 0.71 0.16 0.061 C2H6/CH4: 0.23 0.1 0.033 0.12 0.25 C2H4/C2H6: 5.56 8.75 21.3 18.8 18.6 C2H2/C2H4: 0.8 0.86 0.93 0.95 0.61 CO2/CO: 21.7 20.9 33.4 33 41.2 N2/O2: 4.84 7.45 2.77 2.53 3.11 Jämviktstryck 0 C: 114 113 1370 1284 mbar Jämviktstryck 20 C: 111 108 1309 1211 mbar Jämviktstryck 50 C: 109 105 1256 1144 mbar Gashalt i olja (NTP): 0.70 0.65 6.84 7.21 6.34 %vol@ntp Analyskommentarer: Avgasaren fungerar på avsett vis. Vv ange antalet omsättningar samt antal kopplingar på viklingskopplaren. Återföres avgasad olja till botten? Om så är fallet är provet ifrån botten i princip ett prov ifrån avgasaren. Ett rättvisande prov skall tas på avgasarens ingångssida eller ifrån trafons kylkrets. Adress huvudkontor Bigaråvägen 2 435 43 PIXBO Telefon 031-3381980 Telefax 031-3381774 Adress Laboratoriet Box 189 721 05 Västerås Telefon 021-198017 Telefax 021-181980