WG-MSU05 Master Unit The that EN54 Feat EN54-16 EVAC Certified Emergency Voice Alarm TALAT UTRYMNINGSLARM EN54-16 CERITIFIERAT Wayguard är ett komplett EN54-16 certifierat talat utrymningslarm och public adress system, som också styr, övervakar spelar och distribuerar bakgrundsmusik, reklamjinglar, utrop och meddelanden för upp till 108 zoner. Up 2x Ba In In In Ma Li Gr Sp Sy 2x Au 24 19 Komplett EN54-16 certifikat på hela systemet, från förstärkare till kontroll-enhet, mjukvaror, utropsmikrofoner, batteri-backup och IP-66 klassade WG-ESU08 EN54-24 Slave högtalare. Unit Wayguard-systemet utvecklas och tillverkas i Italien, och är mycket konkurrenskraftigt jämfört mot liknande EN-54 certifierade system, både vad det gäller kvalitet, skalbarhet och pris, men slår även de flesta systemen på fingrarna när det gäller användarvänlighet, installationseffektivitet och flexibilitet. Tack vare den modulbyggda arkitekturen med insticksmoduler är det mycket enkelt att lägga till zoner efteråt, installation och setup är också en av de stora fördelarna då systemet är smart och känner av zonerna. Mjukvaran är överskådlig och flera djup på användare och administratörer kan ställas in. Wayguard är totalt övervakat i alla leden från signal, audio och talade meddelanden till interna kretsar, förstärkare och högtalare, med upp till 5 prioriterings-steg för talat larm. The When Units to ex Feat Pa Up Up Se se Sp 24 19 Det är få system som är äkta EN54-16 certifierade, BEST många Configuration system är, Software vad tillverkaren kallar för: compliant, där utrymningslarmet tillverkas och designas efter vissa riktlinjer men är inte certifierat, Wayguard är helt EN54-16 Certifierat för installation i Europa Tel: 08-92 86 00, Mail: info@prophon.se, hemsida: www.prophon.se 1 The and d BEST Ob Va As
Vad är EN54-16 och när skall det installeras? I april 2011 trädde EN54-16 och EN54-24 i kraft, vilket kortfattat innebär att ljudinstallationer i publik miljö skall vara kopplat till brandlarm och ha talat utrymningslarm, samt uppfylla vissa krav. Vidare måste systemet aktivt övervakas, där så väl kablar som högtalare, förstärkare och elektronik övervakas, med automatisk backuplösning för så väl ström som förstärkare. Wayguard överser allt detta automatiskt och slår direkt över till backupsystem ifall något fel uppstår, samtidigt som administratören varnas om fel. Exempel på EN-54 installationer: Vilka standarder finns under EN54 för ljud? - Köpcentrum och butiker EN54-16 talat utrymningslarm - Konferensanläggningar & Biografer EN54-4 batteribackup - Flygplatser och tågstationer EN54-24 högtalare - Konserthus och teatrar - kryssningsfartyg och nöjesparker - Restauranger och nattklubbar - Offentliga byggnader, skolor Keeping your public safe WayGuard is the solution for demanding public address and emergency sound applications. It is the choice for public announcements, background music, voice evacuation and other applications that require installation and operational versatility, outstanding audio quality and absolute clarity. Proven performance Wayguard is a complete, fully featured and fully scalable public address emergency sound system, leading in performance, ease of use and reliability. The tailored solution Wayguard was designed for medium and large public address and voice alarm applications, but thanks to its extreme flexibility, Wayguard is the choice for any building size. Its matrix arrangement allows up 108 zones and 108 microphone stations. The integrated management and monitoring allow Wayguard to configure the system with power amplifiers sized on the loudspeaker line design. Wayguard is featured to send dedicated and independent recorded messages on each zone. Integrity and clarity: always! Wayguard voice evacuation system is fully supervised to ensure spoken or recorded messages integrity by constantly monitoring the operation of audio and data paths from the microphone capsule, to the internal circuitry, power amplifiers and loudspeaker lines. The built-in redundancy management that automatically switches to spare power amplifiers is a guarantee for continuity of operation. In-house design, no compromise manufacturing Wayguard is totally designed and manufactured by an inhouse team of highly skilled engineers and product experts. We are proud of the know-how we have gained but we constantly outlook to increase our knowledge. Our products are manufactured in our facility with the finest components available and under the strictest factory process control as prescribed by EN54-16 certification. A complete solution Wayguard is heart of Shiratech s voice evacuation system that is composed of master and slave units, line controllers, microphone stations and communication modules. These are integrated by a selected range of accessories such as certified high efficiency class D power amplifiers, and loudspeakers. Not just compliant; Wayguard is certified Wayguard is designed and certified according to the European Standard EN 54-16 that is mandatory in the EU, but recognized in many countries around the world. 2 Tel: 08-92 86 00, Mail: info@prophon.se, hemsida: www.prophon.se
Made in Italy PRODUKTER WG-MSU05 Master Unit The Master Unit is the heart of the Wayguard system. This is the main controller that manages all events, audio flows and performs the monitoring according to EN54-16 requirements. Up to 5 plug-in slots for line and amplifier management modules 2x microphone busses allowing up to 108 stations Background music RCA input Independent volume and tone controls on each zone Internal usd allows to store infinite general purpose or alarm messages Integrated digital audio player Manual silencing on each zone; 5x priority level for each spoken or live message Link to slave modules for extensions up to 108 zones Graphic display with intuitive menu, smart navigation keyboard, status leds Spare amplifier input/output Systems and power supply status reporting through NO/NC contacts. 2x monitored message triggers Auxiliary slot for communication modules (LAN, RS232) 24Vdc operation 19 2U Rack-mountable chassis WG-ESU08 Slave Unit The slave unit carries all the hardware features to extend the Wayguard system. When configuring voice evacuation equipment for large buildings, several Slave Units may be stacked to the WG-MSU05 Master and fit them with line controllers to extend the number of zones. Pass through links to Master unit and other slave units Up to 13 slave units may be stacked to configure the system up to 108 zones Up to 8 plug-in slots for modules line management modules Self addressing of each line module allows an easy and straightforward system setup Spare amplifier input/output 24Vdc operation 19 2U Rack-mountable chassis BEST Configuration Software The BEST configuration software is your tool to design your Wayguard application and download configuration into the hardware through the Master Unit s USB port BEST Lite comes a a standard with WG-MSU05 Master Unit Object-based system design Validation of hardware setup Assignment of zones, levels, priorities, recorded messages, microphone stations Enablement of monitoring and security features BEST Advanced Improved graphical design interface Reports generation and export Message scheduler Tel: 08-92 86 00, Mail: info@prophon.se, hemsida: www.prophon.se 3
MODULER WG-LMM01 Main Zone Controller The line controller that is plugged in the master or in the slave slots, is the system frontend to power amplifier and loudspeaker line. Plugs into master or slave units Independent 32bit microprocessor Self addressing for easy and straightforward system setup Onboard volume and tone controller making audio controls independent for each zone Up to 500W power handling Smart loudspeaker line monitoring through FFT algorithm; +/-5% impedance measurement accuracy; open an short circuit detection. Tracking and self adaptation to slow loudspeaker parameters degeneration due to aging Smart amplifier monitoring through FFT algorithm; normal operation, overload and no-signal detection Automatic switchover spare amplifier in case of main amplifier fault Integrated line calibration allows automatically find the 0dB of zone volume by setting the amplifier drive for 100V output on loudspeaker line Onboard digital audio player and mass memory (independent from master s player) allowing to store and play 2x messages, max 2min each 2x monitored message triggers dedicated to the zone Balanced isolated transformer coupled output to power amplifier Status leds Fast-wiring headers WG-LRM01 Slave Zone Controller The slave line controller is designed to operate in conjunction with the WG-LMM01 line module in those setups where two loudspeaker lines (A+B line) are required. Both modules share the same power amplifier, but keep independent loudspeaker line monitoring. Plugs into master or slave units Independent 32bit microprocessor Self addressing of each line module allows an easy and straightforward system setup Up to 500W power handling Smart loudspeaker line monitoring through FFT algorithm; +/-5% impedance measurement accuracy; open an short circuit detection. Tracking and self adaptation to slow loudspeaker parameters degeneration due to aging Automatic switchover spare amplifier in case of main amplifier fault Status leds 24Vdc operation Fast-wiring headers WG-ELM01 Ethernet Controller The Ethernet module, to be installed in the WG-MSU05 Unit, allows to link two or more Wayguard systems. Any audio content may be forwarded and played on any zones of any sub-system. Shielded RJ45 networking port TCP-IP based communication;10/100 Mbps data transfer Fully supervised data-link according to EM54-16 statements WG-SCC01 RS232 Module The RS232 module adds connectivity to the Wayguard System in those applications where remote logging and data reporting is required Standard DB9 RS232 Port Configurable status reporting Logs download 4 Tel: 08-92 86 00, Mail: info@prophon.se, hemsida: www.prophon.se WG-DPAxxx Series Power Amplifiers Our range of power amplifiers is designed to operate with the Wayguard system and to give the widest scalability and versatility to your setup allowing to feed
MIKROFONER WG-MTU01 Microphone Station Basic microphone console with push-to talk button that may be used for voice evacuation and/or general purpose announcements Dynamic microphone capsule Automatic audio compressor Microphone capsule monitoring according to EM54-16 statements Heavy-duty machined, polished and anodized aluminum to top panel WG-MTU06 Microphone Station Versatile microphone console with direct access keyboard and push-to talk button that may be used for voice evacuation and/or general purpose announcements. Dynamic microphone capsule Automatic audio compressor Microphone capsule monitoring according to EM54-16 statements 6 buttons keyboard for direct access to audio zones and audio contents Heavy-duty machined, polished and anodized aluminum to top panel Digital and monitored interfacement to the WG-MSU05 Master unit WG-MTU10 Microphone Station Fully featured microphone console with dial keyboard and push-to talk button that may be used for voice evacuation and/or general purpose announcements. Dynamic microphone capsule Automatic audio compressor Microphone capsule monitoring according to EM54-16 statements Graphic LCD Display Full dial keyboard for direct access to audio zones and audio contents Heavy-duty machined, polished and anodized aluminum to top panel Digital and monitored interfacement to the WG-MSU05 Master unit WG-EFM10 Microphone Station Emergency PPT microphone station in a hardcase with key-lockable front door. Dynamic microphone capsule Automatic audio compressor Microphone capsule monitoring according to EM54-16 statements Heavy-duty powder coated wall mountable steel box Digital and monitored interfacement to the WG-MSU05 Master unit Tel: 08-92 86 00, Mail: info@prophon.se, hemsida: www.prophon.se 5
more Wayguard systems. Any audio content may be forwarded and played on any zones of any sub-system. FÖRSTÄRKARE Shielded RJ45 networking port TCP-IP based communication;10/100 Mbps data transfer Fully supervised data-link according to EM54-16 statements BATTERI-BACKUP The RS232 module adds connectivity to the Wayguard System in those applications where remote logging and data reporting is required WG-SCC01 RS232 Module Standard DB9 RS232 Port Configurable status reporting Logs download WG-DPAxxx Series Power Amplifiers Our range of power amplifiers is designed to operate with the Wayguard system and to give the widest scalability and versatility to your setup allowing to feed the loudspeaker zone with no more no less the power that that it needs. WG-DPAxxx range of amplifier come in four different packages with 3 different output powers. All power amplifiers are certified as accessories to EN54-16 systems WG-DPA241 WG-DPA501 WG-DPA242 WG-DPA124 single channel 240Wrms single channel 500Wrms twin channel 240Wrms on each channel quad channel 120W on each channel Common features to all models: Compact 1U standard Rack size Class D power stage 220V ac with embedded Power Factor Corrector and 24dc inputs Balanced audio input, +/-385mV sensitivity 100V transformerless loudspeaker output Frequency response: 80Hz 18Khz S/N Ratio: >85dB Volume control and status monitor in front panel Full dial keyboard for direct access to audio zones and audio contents Heavy-duty machined, polished and anodized aluminum to top panel Digital and monitored interfacement to the WG-MSU05 Master unit On multichannel layouts, each channel is a stand-alone unit WG-BPUxxx Series Backup Power Supplies WG-BPU040 960W power out WG-BPU150 3600W power out EN54-4 permanent and emergency power supply unit in 2U rack mount chassis. Self diagnostics and battery fault monitoring State reporting to WG-MSU05 master unit WG -BPU040: 40A-24V outputs, max battery capacity 110A/h, 6A charger WG -BPU150: 150A-24V outputs, max battery capacity 225A/h, 12A charger (units are sold without batteries) 6 Tel: 08-92 86 00, Mail: info@prophon.se, hemsida: www.prophon.se
HÖGTALARE WG-ELD01 Ceiling 5 Loudspeaker Full range indoor EN54-24 Certified ceiling loudspeaker. Power rating @100V 6W-3W-1.5W SPL: 92dB @ 1W/1m Frequency response: 180-20.000Hz Conical 100 dispersion Steel enclosure, white color Ceramic terminal blocks WG-ELD02 Horn Loudspeaker Full range indoor/outdoor EN54-24 Certified ceiling loudspeaker, IP66 rated Power rating @100V 30W-15W-7.5W-3.75W SPL: 108dB @ 1W/1m Frequency response: 340-9.000Hz Conical 60 dispersion Light gray anti-fire ABS Ceramic terminal blocks Dimensions: 212x280mm WG-ELD03 5 Sound Projector Full metal indoor/outdoor EN54-24 Certified sound projector, IP66 rated Power rating @100V 20W-10W-5W SPL: 91dB @ 1W/1m Frequency response: 130-20.000Hz Conical 100 dispersion White coated all metal enclosure Ceramic terminal blocks Dimensions: 140x207mm WG-ELD04 Bass Reflex Monitor Full metal indoor EN54-24 Certified two way bass reflex monitor 5 woofer, 1 horn loaded driver Power rating @100V 30W-15W-7.5W-3.75W-off-8ohm SPL: 89dB @ 1W/1m Frequency response: 80-20.000Hz White anti-fire ABS Ceramic terminal blocks Dimensions: 242x192x190mm Tel: 08-92 86 00, Mail: info@prophon.se, hemsida: www.prophon.se 7
EXEMPEL 8 Tel: 08-92 86 00, Mail: info@prophon.se, hemsida: www.prophon.se
LAYOUT WG-MSU05 Tel: 08-92 86 00, Mail: info@prophon.se, hemsida: www.prophon.se 9
Your distributor: BOX 7268, 187 14 TÄBY Linjalvägen 10C, 187 66 TÄBY Tel: 08-92 86 00 www.prophon.se www.prophon.se is a brand of Sotis Engineering Srl 10 Strada Volpiano 66, 10040 Leini (TO) - Italy WayGuard från Shiratech Tel: +39.011.550.21.29 distribueras i Sverige av Prophon Audio & teknik AB Tel: 08-92 86 00, Fax: Mail: +39.011.550.27.01 info@prophon.se, hemsida: www.prophon.se
Tel: 08-92 86 00, Mail: info@prophon.se, hemsida: www.prophon.se 11