Reservdelskatalog Parts Catalogue PARK 12 HST Season 1990

Transkript

1 Season 1990 Use GLOBAL GARDEN PRODUCT Genuine Spare Parts specified in the parts list for repair and/or replacement. The contents described in the parts list may change due to improvement. The drawings of the spare parts are only indicative and might not represent the part in question exactly. The indications right - left - front - rear refer to the position of the operator when using the machine. When placing orders of parts for repair and/or replacement, make sure that the illustrated parts list is the one applying to the machine s year of manufacture, as shown on the identification plate attached to the machine. Copyright 2014 Global Garden Products All rights reserved. No part of this material may be reproduced or transmitted, in any form or by any means, electronic or mechanical, including photocopying, recording or by any information storage and retrieval system, without permision in writing from GLOBAL GARDEN PRODUCTS.

3 Utga va Issue Ram Frame Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Motorlucka5-01 Engine Cover (Black) Motorhuv 1-00 Engine Hood Popnit Tap/D/Bs 416 Gf9.5 Pop Rivet Knopp Knob Gummistropp (3 St) Rubber Strap (3 Pcs) Bricka Washer Skruv Screw Mutter Nut Skruv Screw Smörjkopp Kort Rak Grease Dispenser Midjegaffel M Ledaxel 5-01 H-10 Clevis Ledaxelstopp Pivot Shaft Stop Spännstift Locating Pin Skruv Screw Skruv Screw Stödplåt Support Plate Skruv Screw Skruv Screw Plate Plate Framskärm Höger1-00 Mudguard,Rh (Yellow) Framskärm Vänster1-00 Mudguard,Lh (Yellow) Skruv Screw Fjäder Spring Skruv Screw Bricka Washer Centrumaxel Centre Shaft Ledlager Ge17Es Bearing Spännstift Locating Pin Framaxeltapp Front Axle Bricka Washer Sitskonsol-gul Seat Bracket-Yellow Huvstöd Par Engine Cover Support Durkmatta Park Hst Floor Mat Frontdekor Front Trim Plate Däck Tyre Däck Tyre Ventil Valve Assy Kullager Ball Bearing Fälg kpl Rim assy Spring Pin Spring Pin Bricka Washer SaxSprint 4X30 Fz Split Pin Bricka Washer Skruv Screw Mutter Låsmutter Nut Täckbricka Kpl.5-01 Instrument panel Bricka Washer Mutter Strålkastare Nut Working lamp Copyright 2014 Global Garden Products 3 STIGA Season 1990

7 Utga va Issue Engine - Brake System Engine - Brake System Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Skruv Screw Skruv Screw Kil Key Mutter Nut Packning Gasket Avgasrör Exhaust pipe Distans Spacer Låsbleck Lock Skruv Screw Värmeskydd (5-01 F12)20 Heat Protection Skruv Screw Ljuddämpare Silencer Klämma F Ljuddämp D35 Rid Clamp Mutter Nut Oljeavtappningsrör Kpl. Oil Drain Pipe O-Ring 11,3 X 2,4 O-ring Plugg Plug Packning Gasket Protection Strip Tanklock Petrol Cap Slangklämma Clamp Kantskyddslist Protection Strip Fäste Bracket Skruv Screw Pedalgummi Pedal Rubber Bromspedal (vä sida) Brake pedal (L. H.) Lager (4 St) Bearing Gasreglage Throttle Cable Knopp Knob Skruv Screw Skruv Screw Skruv Screw Spärr Stop Stag F Parkeringsbroms Stay Nit Kn 5X12 Rivet Starlockbricka Starlock Motorbromswire Cable, Thread Engine Brake Fjäder Spring Fjäder Spring Bränsleslang Petrol tube Insats För Ljuddämpare Pipe-Silencer Ljuddämparklämma Clamp Mutter Nut Fjäder Brake Spring Copyright 2014 Global Garden Products 7 STIGA Season 1990

11 Utga va Issue Drivpedal Farthållare Drive Pedal Cruise Control Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Pedal Pedal Lager Bearing Fäste Bracket Skruv Screw Mutter Nut Arm Kpl. Arm Fartreglagewire Speed Control Wire Spännstift Pin Fästbygel Attaching Clamp Skruv Screw Reglagestång Control rod Knopp Knob Fäste Bracket Kabelgenomföring Cable Protection Skruv Screw Starlock Locking washer Vinkellänk As8 Din 71802M5 Elbow Link Distans Spacer Arm Kpl. Arm Bricka Washer Skruv Screw Skruv Screw Skruv Screw Mutter Nut Underläggsbleck Clamp Plate Magnet Magneto Fjäder Spring Arm Kpl. Lever Plate Plate Brytare Switch Kablage Cover Plate Relä Relä Relay Symbolplatta (Grön) Symbol Plate-Cruise Contr Brytarkonsol Switch console Brytare Switch Skruv Screw Copyright 2014 Global Garden Products 11 STIGA Season 1990

13 Utga va Issue Transmission Transmission Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Skruv Screw Mutter Nut Mutter Nut Spännrulle (Svart) Tension Roller (Black) Distans Spacer Fartreglagewire Speed Control Wire Kilrem V-Belt Spännstift Pin Spännarm Tension Arm Fjäder Spring Skruv Screw Skruv Screw Skruv Screw Bricka Washer Oljebronslag12X18X12-24X3 Flanged Bearing Bricka Washer Segersäkringsäkring Sga10 Circlip Fäste Bracket Skruv Screw Bricka Washer Kullager Ball Bearing Mutter Nut Skruv Screw Skruv Screw Transaxel Transaxle Innerslang Inner Tube Däck Tyre Däck Tyre Ventil Valve Assy Skruv Screw Kil Key Fälg-bak Rim-rear Skruv Screw Mutter Nut Vinkellänk As8 Din 71802M5 Elbow Link Hydrostat Hydrostatic Transmission Skruv Screw Skruv Screw Distans Spacer Stay Stay Distans Spacer Remskiva Belt Pulley Kil Key Fläkt Fan Bricka Washer Skruv Screw Nipple Nipple röduceringsnippel Nipple Slangklämma Hose clamp Copyright 2014 Global Garden Products 13 STIGA Season 1990

15 Utga va Issue Transmission Transmission Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Arm Kpl. Arm Bricka Washer Mutter Låsmutter Nut Oljetank Oil Tank Tanklock Filler Cap Fästband5-01 Band Skruv Screw Mutter Strålkastare Nut Working lamp Kablage Bunband Buntband Cable harness Cable Cable Holder Motorremskiva Engine Pulley Kabel Wire Brytare Switch Mutter Nut Fjäder Spring Pivotplatta Kpl. 24 Pivoting Plate Arm Kpl. Arm Skruv Screw Skruv Screw Mutter Nut Slang Tube Skruv Screw Stag Kpl Rod Fäste Bracket Fjäder Spring Plugg (Service) Vent Plug Copyright 2014 Global Garden Products 15 STIGA Season 1990

17 Utga va Issue Elsystem Electrical System Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Strålkastare Kpl Headlamp Assy Glödlampa 12336H3 12 Glow Lamp Skruv Screw Skruv Screw Bricka Washer Elkabel Cable Brytare Switch Tändningslås Kpl Service Starter Switch Assy Tändningsnyckel Ignition Key Brytare Switch Fl.Stift 3868 F/45Msblk Cable Connection Kabel Wire Skruv Screw Kablage Bunband Buntband Cable harness Cable Cable Holder Kabelhärva Cable Harness Låsbleck Clamp Skruv Screw Kabel Cable Skruv Screw Säkringshållare Fuse Box Säkring 8A Fuse 8A Kabel Cable Batterikabel (-) Battery Cable (-) Batterikabel (+) Battery Cable (+) Batteri Battery Batteriunderlägg Battery Pad Batterihållare Battery Holder Kabelgenomföring O 26 Cable Protector Flatst.Hylsa A2507 Flh-1 Cable Connection Mutter Nut Batteriskydd Guard Cap (+) Batterisyra Battery Acid 2 x 0.85 liter Solenoid Kpl Service Solenoid Stift Cable Connection Mutter Nut Skyddshätta Guard Cap Copyright 2014 Global Garden Products 17 STIGA Season 1990

19 Utga va Issue Styrning Steering Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Linhjul Steering Pulley Sats 2 st/kit of Linhjul Steering Pulley Bussning Bushing Fäste Bracket Skruv Screw Mutter Nut Bricka Washer Kedjehjul Sprocket Bussning Bushing Skruv Screw Skruv Screw Kedja79 Länkar Chain W/O Lock Kedjelås Chain Lock Styrwire Steering Cable Left L = 939 mm Styrwire Steering Cable,Rh L = 990 mm Fjäder Spring Fjäder Spring Bricka Washer Mutter Låsmutter Nut Ratt Steering Wheel Ratt Steering Wheel Spännstift Locating Pin Bricka Washer 1.0 mm Bricka Washer 0.5 mm Rattrör Nedre Steering Column,Lower Lager Bearing Skruv Screw Rattstång Steering Rod Distans Spacer Copyright 2014 Global Garden Products 19 STIGA Season 1990

23 Utga va Issue Kanzaki Transaxel K110 Kanzaki Transaxle K110 Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Sealant Sealant /K Bricka Washer /K Sealant Sealant /K Bricka Washer /K Bricka Washer /K Drev Differential Gear /K Sealant Sealant Bricka Washer Drev Differential Gear Transmission case Transmission case /K Motordrev Kpl Motor Gear Assy /K Motordrev Kpl Motor Gear Assy /K Axel Pinion shaft /K Transmission case Transmission case Motordrev Kpl Motor Gear Assy Axel Pinion shaft Upper case Upper case Drev Differential pinion Vent valve assy Vent valve assy Case Case Huvudaxel Main Shaft /K Bricka Washer /K Huvudaxel Main Shaft Bricka Washer Shims (Sats) Shim Assy /K Kullager Ball Bearing /K Shims (Sats) Shim Assy Kullager Ball Bearing Hus-nedre Lower Case Bult Bolt Plugg Plug Mutter Nut Plugg Plug Mellanaxel Idle Shaft /K Packning Packing /K Mellanaxel Idle Shaft /K Packning Packing /K Drev (24) Gear (24) /K Packning Packing /K Drev (24) Gear (24) /K Packning Packing /K Bricka Thrust /K Packning Packing /K Bricka Thrust /K Packning Packing /K Nållager Needle Bearing /K Skruv Screw /K Nållager Needle Bearing /K Skruv Screw /K110 Copyright 2014 Global Garden Products 23 STIGA Season 1990

25 Utga va Issue Kanzaki Transaxel K110 Kanzaki Transaxle K110 Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Kullager Ball Bearing /K Skruv Screw /K Kullager Ball Bearing /K Skruv Screw /K Kullager Ball Bearing /K Skruv Screw /K Kullager Ball Bearing /K Skruv Screw /K110 Copyright 2014 Global Garden Products 25 STIGA Season 1990

27 Utga va Issue Kanzaki Transaxel K110 Kanzaki Transaxle K110 Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Drev kpl Final pinion assy /K Bricka Washer /K Bricka Washer /K Bromstrumma Brake Drum /K Bricka Washer /K Bromstrumma Brake Drum /K Drev kpl Final pinion assy Bricka Washer Bromstrumma Brake Drum Axel Vä Axle Shaft L. Mask. sedd framifrån/ K Axel Vä Axle Shaft L. Mask. sedd framifrån Broms Kpl Brake Assembly /K Broms Kpl Brake Assembly Axle shaft-r.h. Axle shaft-r.h. Mask. sedd framifrån/ K Axle shaft-r.h. Axle shaft-r.h. Mask. sedd framifrån Bromsback Brake Shoe /K Bromsback Brake Shoe Drev Final gear /K Nållager Needle Bearing /K Nållager Needle Bearing /K Fjäder Spring /K Drev Final gear Nållager Needle Bearing Fjäder Spring Kullager Ball Bearing /K Låsring Ring /K Kullager Ball Bearing /K Låsring Ring /K Bromslock Brake Cover /K Låsring Ring /K Bromslock Brake Cover /K Låsring Ring Bromslock Brake Cover Kullager Ball Bearing /K Tätning Seal /K Kullager Ball Bearing /K Tätning Seal Låsring Ring /K Bult Bolt /K110 Copyright 2014 Global Garden Products 27 STIGA Season 1990

29 Utga va Issue Carburettor Carburettor Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Packning Gasket Ventil Valve Skruv Screw Skruv Screw Fjäder Spring LåsSprint Pin Axel Shaft Chokespjäll Choke valve Nålventil Needle valve Rep.sats Overhaul kit Delarna märkta F Skruv Screw Förgasare kpl Carburettor Assy Förgasare kpl Carburettor Assy Förgasare kpl Carburettor Assy Förgasare kpl Carburettor Assy Carurettor body Carurettor body Förgasare Carburetor Carurettor body Carurettor body Förgasare Carburetor Täckbricka Welch plug Venturirör Venturi Gasspjäll Throttle Valve Spjällaxel Shaft Axelstopp Stop Flottör Float Bränslenål Inlet valve _/ Kit: F Bränslenål Inlet valve _/ Kit: F Bränslenål Inlet valve Bränslenål Inlet valve Flottörhus Bowl Packning Gasket Bricka Washer Axel Shaft Chokeaxel Choke shaft Chokeaxel Choke shaft Axel Shaft Munstycke Nozzle Munstycke Nozzle Mutter Nut Nippel Connector Bränsleledning Fuel line Shut-off valve Shut-off valve Connector Connector Choke link Choke link Skruv Screw Bränslefilter Fuel Filter Bränslefilter Fuelfilter Bränslefilter Fuel Filter Bränslefilter Fuelfilter Copyright 2014 Global Garden Products 29 STIGA Season 1990

31 Utga va Issue Carburettor Carburettor Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Skruv Screw Startmotor Starting motor Bult Bolt Släpkol Brush Tändsystem kpl Armature group Skruv Screw Skruv Screw Bränslepump Impulse pump Skruv Screw Pappersfilter Cartridge Låsratt Knob Generator Alternator Stator Alternator stator Stator Alternator stator Generator Alternator Skruv Screw Drev kpl Drive assy Koppling kpl Clutch Ass.Y Bränsleledning Fuel line Skruv Screw Skruv Screw Filterelement Element Packning Gasket Startarmatur Armature Bricka Washer Slangklämma Hose clamp Fjäder Spring Bricka Foam washer Fäste Bracket Skruv Screw Kuggkrans Gear ring Skyddskåpa Cover Skruv Screw Drev Gear Lock End cap Botten End cap Hus Housing Anslutning Terminal Rep.sats bränslepump Repair Kit Lock Cover Filterhus Body Startdrev Retainer kit Connector Connector Anslutning Connector Connector Connector Anslutning Connector Kabelhärva Harness Stift Roll pin Handtag Handle Copyright 2014 Global Garden Products 31 STIGA Season 1990

35 Utga va Issue Cylinder Cylinder Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Cylinder kpl Cylinder Assy Lager Bearing Tätningsring Seal Topplock Cylinder Head Packning Gasket Vevhusventilation Breather Vevhusventilation Breather Vevhusventilation Breather Vevhusventilation Breather Packning Gasket Skruv Screw Rör Tube Packning Gasket Skruv Screw OljePlugg Oil plug Vevaxel Crankshaft Vevhus Oil sump Tätningsring Oil Seal Oil seal Skruv Screw Svänghjul Flywheel Kil Key Kolv kpl Piston Assy Kolvringssats Ring set Låsring Lock Kolvsprint Piston Pin Vevstake kpl Connecting rod assy Låsbleck Lock Skruv Screw Utblåsningsventil Exhaust valve Insugningsventil Intake valve Ventilfjäder-insug Valve spring-intake Ventilfjäder-utblås Valve spring-exhaust Skydd Cover Hållare Retainer Rotator Rotocoil Hållare Retainer Ventillyftare Valve tappet Kamaxel Camshaft Bricka Washer Skruv Screw Skruv Screw Regulatorlänk Governor link Fjäder Spring Oljekastardrev Oil slinger gear Governor plate Governor plate Regulatorplatta Governor plate Regulatorplatta Governor plate Governor plate Governor plate Regulatoraxel Governor crank Copyright 2014 Global Garden Products 35 STIGA Season 1990

37 Utga va Issue Cylinder Cylinder Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Arm Lever Bricka Washer Fjäder Spring Klämma Clamp Skruv Screw Blower housing Blower housing Fläkthus Blower housing Blower housing Blower housing Fläkthus Blower housing Skruv Screw Skyddsplåt Shield Skruv Screw Skydd Cover Mutter Nut Tändstift (J19Lm) Spark Plug (J19Lm) Skruv Screw Bricka Washer Mutter Nut Kortslutningskabel Ground wire Packning Packningssats Gasket Gasket set Delarna märkta S Avdragare Puller Tillbehör/Accessory Tändstiftsnyckel (19 Mm-21 Mm) Spark Plug Wrench (19 Mm-21 Tillbehör/Accessory Mm) Bygel Clamp Kopp Cup Skyddsnät Screen Anslutningsbleck Terminal Oljesticka Oil dipstick Tätning Seal Rör Tube Bussning Bushing Skruv Screw Mutter Nut Låsnål Cotter Pin Cotter pin Låsring Retainer Stop switch Stop switch Tändstiftsskydd Spark plug elbow Skruv Screw Skruv Screw Drev Gear Länk Link Balanseringsvikt Counterweight Kolvsprint Piston Pin Skruv Screw Tätning Seal Oljesticka kpl Oil filler group Ventilsäte Valve seat Ventilsäte Valve seat Ventilstyrning-insug Valve guide-intake Copyright 2014 Global Garden Products 37 STIGA Season 1990

39 Utga va Issue Cylinder Cylinder Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Ventilstyrning-utblås Valve guide-exhaust Packning Gasket Isolator Insulator Fläkt Fan Fläkthållare Fan retainer Distans Spacer Excenter Eccentric Stift Pin Copyright 2014 Global Garden Products 39 STIGA Season 1990

40 code pos. q.ty page p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p. 27 Copyright 2014 Global Garden Products 40 STIGA -

41 code pos. q.ty page p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p. 31 Copyright 2014 Global Garden Products 41 STIGA -

42 code pos. q.ty page p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p. 35 Copyright 2014 Global Garden Products 42 STIGA -