Reservdelskatalog Parts Catalogue VILLA 8E Season 1989

Transkript

1 Season 1989 Use GLOBAL GARDEN PRODUCT Genuine Spare Parts specified in the parts list for repair and/or replacement. The contents described in the parts list may change due to improvement. The drawings of the spare parts are only indicative and might not represent the part in question exactly. The indications right - left - front - rear refer to the position of the operator when using the machine. When placing orders of parts for repair and/or replacement, make sure that the illustrated parts list is the one applying to the machine s year of manufacture, as shown on the identification plate attached to the machine. Copyright 2014 Global Garden Products All rights reserved. No part of this material may be reproduced or transmitted, in any form or by any means, electronic or mechanical, including photocopying, recording or by any information storage and retrieval system, without permision in writing from GLOBAL GARDEN PRODUCTS.

3 Utga va Issue Förgasare Bränsle- Och Elsystem Carburettor Fuel- And El.System Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Packning Gasket Ventil Valve Skruv Screw Skruv Screw Fjäder Spring LåsSprint Pin Axel Shaft Chokespjäll Choke valve Nålventil Needle valve Rep.sats Overhaul kit Skruv Screw Förgasare kpl Carburettor Assy Förgasare Carburetor Täckbricka Welch plug Venturi Venturi Gasspjäll Throttle Valve Spjällaxel Shaft Axelstopp Stop Flottör Float Bränslenål Inlet valve Flottörhus Bowl Packning Gasket Bricka Washer Axel Shaft Munstycke Nozzle Munstycke Nozzle Bricka Washer Fuel tank Fuel tank Tanklock Fuel Tank Cap Cap Cap Fäste Bracket Fäste Bracket Strap L.H. Strap L.H Strap Strap Skruv Screw Mutter Nut Fuel pipe Fuel pipe Skruv Screw Shut-off valve Shut-off valve Connector Connector Choke link Choke link Starter motor Starter motor Skruv Screw Släpkol Brush Tändsystem kpl Armature group Skruv Screw Skruv Screw Startdrev Drive Koppling kpl Clutch Ass.Y Copyright 2014 Global Garden Products 3 STIGA Season 1989

5 Utga va Issue Förgasare Bränsle- Och Elsystem Carburettor Fuel- And El.System Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Clamp Clamp Skruv Screw Skruv Screw Stöd Support För d:o Luftfilterelement Filter Element Luftfilter kpl Air Cleaner Assy Packning Gasket Armature Armature Slangklämma Hose clamp Fjäder Spring Bricka Foam washer Kopp Cup Fäste Bracket Skruv Screw Distans Spacer Skruv Screw Kuggkrans Gear ring Drev Gear Lock Drive end cap Botten End cap Hus Housing Anslutning Terminal Retainer kit Retainer kit Connector Connector Kabelhärva Harness Stator Stator Stift Pin Handtag Handle Distans Spacer Nät Screen Tätning Seal Copyright 2014 Global Garden Products 5 STIGA Season 1989

7 Utga va Issue Cylinder Vevhus Cylinder Crankcase Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Cylinder Cylinder Bearing Bearing Bearing Bearing Oil seal Oil seal Topplock Cylinder Head Packning Gasket Vevhusventilation Breather Packning Gasket Skruv Screw Rör Tube Packning Gasket Skruv Screw Skruv Screw OljePlugg Oil plug Crankshaft Crankshaft Vevhus Oil sump Bussning Bushing Tätningsring Seal Skruv Screw Flywheel Flywheel Flywheel Flywheel Kil Key Kolv Piston Ring set Ring set Låsring Lock Kolvsprint Piston Pin Connecting Rod Connecting Rod Låsbleck Lock Skruv Screw Exhaust valve Exhaust valve Insugningsventil Intake valve Ventilfjäder-insug Valve spring-intake Ventilfjäder-utblås Valve spring-exhaust Guard Guard Hållare Retainer Rotator Rotocoil Hållare Retainer Valve tappet Valve tappet Kamaxel Camshaft Starthus Housing Pulley Pulley Fjäder Spring Startsnöre (Från 5 Hk) S Starter Rope >5Hp Stift Pin Grip Grip Fjäder Spring Adapter Adapter Skruv Screw Starter clutch Starter clutch Copyright 2014 Global Garden Products 7 STIGA Season 1989

9 Utga va Issue Cylinder Vevhus Cylinder Crankcase Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Kopplingshus Clutch Housing Kula Ball Startspärr Ratchet Bricka Washer Nät Screen Skruv Screw Bricka Washer Bricka Washer Skruv Screw Luftledare Air Guide Governor link Governor link Fjäder Spring Oil slinger gear Oil slinger gear Governor plate Governor plate Regulatoraxel Governor crank Arm Lever Bricka Washer Fjäder Spring Klämma Clamp Skruv Screw Ljuddämpare Muffler Blower housing Blower housing Blower housing Blower housing Skruv Screw Shield Shield Skruv Screw Cover Cover Mutter Nut Tändstift (J19Lm) Spark Plug (J19Lm) Skruv Screw Kortslutningskabel Ground wire Packningssats Gasket set Flywheel puller Flywheel puller Tillbehör/Accessory Mutter Nut Tändstiftsnyckel (19 Mm-21 Mm) Spark Plug Wrench (19 Mm-21 Tillbehör/Accessory Mm) Clamp Clamp Kopp Cup Nät Screen Oil dipstick Oil dipstick Tätning Seal Rör Tube Bussning Bushing Skruv Screw Mutter Nut Starter assy Starter assy Skruv Screw Låsnål Cotter Pin Cotter pin Låsring Retainer Copyright 2014 Global Garden Products 9 STIGA Season 1989

11 Utga va Issue Cylinder Vevhus Cylinder Crankcase Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Stop switch Stop switch Tändstiftsskydd Spark plug elbow Anchor Anchor Skruv Screw Skruv Screw Deflektor Deflector Värmeskydd Heat shield Gear Gear Länk Link Balanseringsvikt Counterweight Kolvsprint Piston Pin Skruv Screw Skruv Screw Tätning Seal Oljesticka kpl Oil filler group Valve seat-intake Valve seat-intake Valve seat-intake Valve seat-intake Ventilstyrning-insug Valve guide-intake Packning Gasket Distans Spacer Excenter Eccentric Stift Pin Copyright 2014 Global Garden Products 11 STIGA Season 1989

13 Utga va Issue Tecumseh Peerless Växellåda 781A 786A Tecumseh Peerless Gearbox 781A 786A Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Växellåda 781B Gear Box 781B 19 Villa 1 1 P Case Case /781A/786A/ 1 1 P A Case Case /781A/786A/ 2 1 P Cover Cover /781A/786A/ 2 1 P A Cover Cover /781A/786A/ 3 1 P Axel Shaft /781A/786A/ 3 1 P Axel Shaft /781A/786A/ 4 1 P A Drev Gear 20T/781A/786A/ 5 1 P A Drev Gear 22T/781A/786A/ 6 1 P A Drev Gear 25T/781A/786A/ 7 1 P A Drev Gear 30T/781A/786A/ 8 1 P Gear Gear 35T/781A/786A/ 9 1 P Hylsa Collar /781A/786A/ 10 1 P Kedjehjul Sprocket 18T/781A/786A/ 11 1 P Kedjehjul Sprocket 9T/781A/786A/ 12 1 P Axel Shaft /781A/786A/ 13 1 P Gear Gear 42T+15T/781A/786A/ 14 1 P A Drev Gear 20T/781A/786A/ 15 1 P A Drev Gear 25T/781A/786A/ 16 1 P A Drev Gear 28T/781A/786A/ 17 1 P A Drev Gear 30T/781A/786A/ 18 1 P Axel Shaft /781A/786A/ 19 1 P A Drev Bevel pinion /781A/786A/ 20 1 P Sprocket Sprocket 21 1 P Bromsskiva Brake Disc /781A/786A/ 22 1 P Bromsarm Brake Lever 23 1 P Hållare Holder /781A/786A/ 24 2 P Bromsbelägg Brake pad /781A/786A/ 25 1 P Tryck platta Brake plate /781A/786A/ 26 2 P TryckSprint Dowel pin /781A/786A/ 27 4 P A Bussning Bushing /781A/786A/ 28 1 P Kedja Chain 24 länk/link/781a/786a/ 29 5 P Bricka Washer /781A/786A/ 30 2 P Nållager Needle Bearing /781A/786A/ 31 1 P Retaining ring Retaining ring /781A/786A/ 32 1 P Låsring Retaining ring /781A/786A/ 33 1 P Bricka Washer /781A/786A/ 34 1 P Låsring Reataining ring /781A/786A/ 35 1 P Shift rod Shift rod /781A/786A/ 36 6 P Skruv Screw /781A/786A/ 36 8 P Skruv Screw /781A/786A/ 37 2 P A Kil Key /781A/786A/ 38 1 P Mutter Nut /781A/786A/ 39 1 P Bricka Washer /781A/786A/ 40 1 P Kula Ball /781A/786A/ 41 1 P Skruv Screw /781A/786A/ 42 1 P Fjäder Spring /781A/786A/ 43 5 P Bricka Washer /781A/786A/ 44 1 P O-ring O-ring /781A/786A/ Copyright 2014 Global Garden Products 13 STIGA Season 1989

15 Utga va Issue Tecumseh Peerless Växellåda 781A 786A Tecumseh Peerless Gearbox 781A 786A Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes 45 1 P Bricka Washer /781A/786A/ 46 1 P Fäste Bracket /781A/786A/ 90 1 P B Grease Grease /781A/786A/ Copyright 2014 Global Garden Products 15 STIGA Season 1989

17 Utga va Issue Tecumseh Peerless Differential A, A A Tecumseh Peerless Differential A, A A Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Differentiell Differential Villa Differentiell Differential Park Differentiell Differential Garden 1 1 P Housing Housing 1 1 P Housing Housing 1 1 P Housing Housing 1 1 P Housing Housing 2 1 P Axel Axle 224 mm (splines) 2 1 P Axel Axle 209 mm (splines) 2 1 P Axel Axle 196 mm (splines) 2 1 P A Axel Axle 196 mm (splines) 3 1 P Axel Axle 449 mm (splines) 3 1 P A Axel Axle 449 mm (splines) 3 1 P Axel Axle 434 mm (splines) 3 1 P Axel Axle 420 mm (splines) 4 2 P Drev Bevel gear 5 2 P Drev Gear 6 1 P Stift Drive pin 7 2 P Bricka Washer 8 2 P Bricka Washer 10 4 P Låsring Snap ring 11 4 P Skruv Screw 13 1 P Bussning Bushing 43 mm 13 1 P Bussning Bushing 13 2 P Bussning Bushing 90 1 P B Grease Grease Copyright 2014 Global Garden Products 17 STIGA Season 1989

19 Utga va Issue Chassi Elsystem Chassis Electrical System Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Motorhuv kpl Engine casing assy Gummistropp (3 St) Rubber Strap (3 Pcs) Bricka Washer Knopp Knob Popnit Tap/D/Bs 416 Gf9.5 Pop Rivet Motorlucka Engine cover Inkl Plugg Plug Gummislang Rubberhose Stötfångare Kpl Tube Smörjkopp Kort Rak Grease Dispenser Mutter Nut Skruv Screw Durkmatta Villa Floor Mat Gummistropp (3 St) Rubber Strap (3 Pcs) Skruv Screw Bricka Washer Gallerinsats Villa Guarding Net Batteri Battery Batteriunderlägg Battery Pad Batteriplatta Battery Plate Batterihållare Battery Holder Skruv Screw Batterikabel (-) Battery Cable (-) Batterikabel (+) Battery Cable (+) Kabelhärva Harness Tändningslås Kpl Service Starter Switch Assy Tändningsnyckel Ignition Key Brytare Switch Skruv Screw Solenoid Kpl Service Solenoid Batteriskydd Guard Cap (+) Batterisyra Battery Acid Bearing Bearing Ej ill/not ill. Copyright 2014 Global Garden Products 19 STIGA Season 1989

21 Utga va Issue Hjulupphängning Broms Wheel Suspension Brake System Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Pedal Kpl 5-01 Brake Pedal Skruv Screw Reglagespak Control Lever Lager 5-01 Bearing Mutter Strålkastare Nut Working lamp Fjäder Spring Bromsstång Brake Rod Skruv Screw Mutter Nut Bakaxelfäste Rear Axle Mounting Bussning Bushing Fälg Rim Fälg Rim Ventil Valve Assy Skruv Screw Däck Tyre 2816, Spårring Sga 20 Circlip Bricka Washer Bakaxel Rear axle Smörjkopp Kort Rak Grease Dispenser Spindel-vä Spindle Lh Axel Shaft For Steering Pulley Spindel-hö Spindle Rh Fälg kpl Rim assy Bussning Bearing Bussning Bearing Däck Tyre Bricka Washer Mutter Nut Mutter Låsmutter Nut Fjäder Brake Spring Bricka Washer Spiralspnst Prym N3X16 Locating Pin Skruvögla Eye Bolt Mutter Låsmutter Nut Halkskydd Slip protection Finland (FIN) Skruvögla Eye Bolt röduceringsnippel Nipple 2816, Copyright 2014 Global Garden Products 21 STIGA Season 1989

23 Utga va Issue Styrning Sits Steering Seat Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Ratt Steering Wheel Spännstift Locating Pin Bricka Washer 1.0 mm Bricka Washer 0.5 mm Spännstift Locating Pin Rattstång Steering Rod Lager Bearing Linhjul Steering Pulley Bussning Bushing Linhjul Steering Pulley Fäste Bracket Skruv Screw Styrwire Steering Wire Mutter Låsmutter Nut Bricka Washer Fjäder Spring Skruv Screw Mutter Nut Lager (4 St) Bearing Bricka Washer Spårring Sga 20 Circlip Mutter Nut Linhjul Steering Pulley Vinkellänk As13 Din 71802M8 Elbow Link Parallellstag Tie Rod Skruv Screw Distans Spacer Skruv Screw Reglagestång Control Rod Starlock Starlock Spännstång Kpl. Rod Distans Spacer Sitskonsol-gul Seat Bracket-Yellow Rör Tube Axel Axle Sitsfjäder Seat spring Fjäder Spring Sitsstång Seat Rod Mutter Nut Parallellstag5-01 F24 Tie Bar Låsbricka Starlock Sitsadapter Seat Adapter Skruv Screw Skruv Screw Bricka Washer Knopp Knob Sitsfäste Kpl Seat Attachment-R.H Sitsfäste Kpl Seat Attachment-L.H. Copyright 2014 Global Garden Products 23 STIGA Season 1989

25 Utga va Issue Styrning Sits Steering Seat Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Sits Sears Sa 1216 ( ) Axel Shaft Starlock Lock washer Mellanstag Shaft Seat Sears Sa 1216 ( ) 20 Copyright 2014 Global Garden Products 25 STIGA Season 1989

27 Utga va Issue Transmission Motor Transmission Engine Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Mutter Nut Kil Key Pedalgummi Pedal Rubber Finland, Frankrik Kopplingspedal Kpl Clutch Pedal Lager 5-01 Bearing Fjäder Spring Spännarm Tension Arm Bricka Washer Bricka Washer Skruv Screw Skruv Screw Remskydd Belt Guard Remskiva Belt Pulley Kilrem V-Belt = Mutter Låsmutter Nut Spårring Sga 16 Circlip Motorremskiva Engine Belt Pulley Spännrulle (Svart) Tension Roller (Black) Mutter Nut Skruv Screw Bricka Washer Distansring Spacer Ring Skruv Screw Remhållare Belt Stirrup Distans Spacer Skruv Screw Mutter Strålkastare Nut Working lamp Skruv Screw Kopplingsstång Clutch Control Rod Skruvögla Eye Bolt Mutter Låsmutter Nut Mutter Nut Spiralspnst Prym N3X16 Locating Pin Halkskydd Slip protection Finland Kil Key Instrumentpanel(5-01 F12) Panel Differentiell Differential Skruv Screw Skruv Screw Gasreglage Throttle Cable Knopp Knob Copyright 2014 Global Garden Products 27 STIGA Season 1989

31 Utga va Issue Power Take-Off Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Kåpfjäder Spring For Casing Spännarm Smst Servicedet Tensioning Arm Compl Kilrem V-Belt = Spännrulle (Svart) Tension Roller (Black) Distans Spacer Mutter Nut Remstyrning Belt Guide Kilrem V-Belt = Länkstång Link Rod Fjäder Brake Spring Bricka Washer Spännarm Tensioning Arm Bricka Washer Mutter Låsmutter Nut Bricka Washer Bricka Washer Mutter Nut Motorremskiva Engine Belt Pulley Spännrulle kpl Tensioning Roller Compl Kullager Ball Bearing Spårring Sgh 35 Circlip Remhållare Belt Stirrup Mellanaxel Shaft Skruv Screw Bricka Washer Skruv Screw Dubbelremskiva Kpl Villa Double V-Belt Pulley Distans Spacer Spårring Sgh 40 Circlip Kullager Ball Bearing Spännarmsfäste Tension Arm Bracket Skruv Screw Skruv Screw Distans Spacer Starlock Starlock Reglagestång Control Rod Bricka Washer Knopp Knob Urkopplingsspak Disengaging Lever Skruv Screw T-Handtag Handle Gear Shifter Skruv Screw Sitskonsol-gul Seat Bracket-Yellow Reglagespak Control Lever Låsbricka Starlock Fjäder Spring Låshake Locking Pawl Bricka Washer Bricka Washer Copyright 2014 Global Garden Products 31 STIGA Season 1989

34 code pos. q.ty page p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p. 19 Copyright 2014 Global Garden Products 34 STIGA -

35 code pos. q.ty page p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p. 7 Copyright 2014 Global Garden Products 35 STIGA -

36 code pos. q.ty page p p p p p p p p p p p p p p p p p p. 9 P p. 13 P p. 13 P p. 17 P p. 17 P p. 17 P p. 17 P p. 17 P p. 17 P p. 17 P p. 17 P p. 17 P p. 17 P p. 13 P p. 13 P p. 13 P p. 13 P p. 17 P p. 13 P p. 13 P p. 17 P p. 17 P p. 13 P p. 17 P p. 17 P p. 13 P p. 17 P p. 13 P p. 13 P p. 17 P p. 13 P p. 13 P p. 13 P p. 17 P p. 13 P p. 13 P p. 13 P p. 15 P p. 13 P p. 13 P p. 13 P p. 13 P p. 13 P p. 13 P p. 13 P p. 13 P p. 13 P p. 17 P p. 13 P p. 13 P p. 13 P p. 13 P p. 13 P p. 13 P p. 13 P p. 13 P p. 15 P p. 17 P A 1 1 p. 13 P A 2 1 p. 13 P A 2 1 p. 17 P A 3 1 p. 17 P A 19 1 p. 13 P A 4 1 p. 13 P A 5 1 p. 13 P A 6 1 p. 13 P A 7 1 p. 13 P A 14 1 p. 13 P A 15 1 p. 13 P A 16 1 p. 13 P A 17 1 p. 13 P A 27 4 p. 13 P B 90 1 p. 15 P B 90 1 p. 17 P A 37 2 p. 13 Copyright 2014 Global Garden Products 36 STIGA -