Reservdelskatalog Parts Catalogue PARK 12 (F) Season 1990

Transkript

1 Season 990 Use GLOBAL GARDEN PRODUCT Genuine Spare Parts specified in the parts list for repair and/or replacement. The contents described in the parts list may change due to improvement. The drawings of the spare parts are only indicative and might not represent the part in question exactly. The indications right - left - front - rear refer to the position of the operator when using the machine. When placing orders of parts for repair and/or replacement, make sure that the illustrated parts list is the one applying to the machine s year of manufacture, as shown on the identification plate attached to the machine. Copyright 204 Global Garden Products All rights reserved. No part of this material may be reproduced or transmitted, in any form or by any means, electronic or mechanical, including photocopying, recording or by any information storage and retrieval system, without permision in writing from GLOBAL GARDEN PRODUCTS.

2 Copyright 204 Global Garden Products 2 STIGA Season 990

3 Utga va Issue Carburettor Carburettor Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Packning Gasket Ventil Valve Skruv Screw Skruv Screw Fjäder Spring LåsSprint Pin Axel Shaft Chokespjäll Choke valve Nålventil Needle valve Rep.sats Overhaul kit Delarna märkta F Skruv Screw Förgasare kpl Carburettor Assy Förgasare kpl Carburettor Assy Förgasare kpl Carburettor Assy Förgasare kpl Carburettor Assy Carurettor body Carurettor body Förgasare Carburetor Carurettor body Carurettor body Förgasare Carburetor Täckbricka Welch plug Venturirör Venturi Gasspjäll Throttle Valve Spjällaxel Shaft Axelstopp Stop Flottör Float Bränslenål Inlet valve _/ Kit: F Bränslenål Inlet valve _/ Kit: F Bränslenål Inlet valve Bränslenål Inlet valve Flottörhus Bowl Packning Gasket Bricka Washer Axel Shaft Chokeaxel Choke shaft Chokeaxel Choke shaft Axel Shaft Munstycke Nozzle Munstycke Nozzle Mutter Nut Nippel Connector Bränsleledning Fuel line Shut-off valve Shut-off valve Connector Connector Choke link Choke link Skruv Screw Bränslefilter Fuel Filter Bränslefilter Fuelfilter Bränslefilter Fuel Filter Bränslefilter Fuelfilter Copyright 204 Global Garden Products 3 STIGA Season 990

5 Utga va Issue Carburettor Carburettor Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Skruv Screw Startmotor Starting motor Bult Bolt Släpkol Brush Tändsystem kpl Armature group Skruv Screw Skruv Screw Bränslepump Impulse pump Skruv Screw Pappersfilter Cartridge Låsratt Knob Generator Alternator Stator Alternator stator Stator Alternator stator Generator Alternator Skruv Screw Drev kpl Drive assy Koppling kpl Clutch Ass.Y Bränsleledning Fuel line Skruv Screw Skruv Screw Filterelement Element Packning Gasket Startarmatur Armature Bricka Washer Slangklämma Hose clamp Fjäder Spring Bricka Foam washer Fäste Bracket Skruv Screw Kuggkrans Gear ring Skyddskåpa Cover Skruv Screw Drev Gear Lock End cap Botten End cap Hus Housing Anslutning Terminal Rep.sats bränslepump Repair Kit Lock Cover Filterhus Body Startdrev Retainer kit Connector Connector Anslutning Connector Connector Connector Anslutning Connector Kabelhärva Harness Stift Roll pin Handtag Handle Copyright 204 Global Garden Products 5 STIGA Season 990

7 Utga va Issue Carburettor Carburettor Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Tätning Seal Copyright 204 Global Garden Products 7 STIGA Season 990

9 Utga va Issue Cylinder Cylinder Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Cylinder kpl Cylinder Assy Lager Bearing Tätningsring Seal Topplock Cylinder Head Packning Gasket Vevhusventilation Breather Vevhusventilation Breather Vevhusventilation Breather Vevhusventilation Breather Packning Gasket Skruv Screw Rör Tube Packning Gasket Skruv Screw OljePlugg Oil plug Vevaxel Crankshaft Vevhus Oil sump Tätningsring Oil Seal Oil seal Skruv Screw Svänghjul Flywheel Kil Key Kolv kpl Piston Assy Kolvringssats Ring set Låsring Lock Kolvsprint Piston Pin Vevstake kpl Connecting rod assy Låsbleck Lock Skruv Screw Utblåsningsventil Exhaust valve Insugningsventil Intake valve Ventilfjäder-insug Valve spring-intake Ventilfjäder-utblås Valve spring-exhaust Skydd Cover Hållare Retainer Rotator Rotocoil Hållare Retainer Ventillyftare Valve tappet Kamaxel Camshaft Bricka Washer Skruv Screw Skruv Screw Regulatorlänk Governor link Fjäder Spring Oljekastardrev Oil slinger gear Governor plate Governor plate Regulatorplatta Governor plate Regulatorplatta Governor plate Governor plate Governor plate Regulatoraxel Governor crank Copyright 204 Global Garden Products 9 STIGA Season 990

11 Utga va Issue Cylinder Cylinder Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Arm Lever Bricka Washer Fjäder Spring Klämma Clamp Skruv Screw Blower housing Blower housing Fläkthus Blower housing Blower housing Blower housing Fläkthus Blower housing Skruv Screw Skyddsplåt Shield Skruv Screw Skydd Cover Mutter Nut Tändstift (J9Lm) Spark Plug (J9Lm) Skruv Screw Bricka Washer Mutter Nut Kortslutningskabel Ground wire Packning Packningssats Gasket Gasket set Delarna märkta S Avdragare Puller Tillbehör/Accessory Tändstiftsnyckel (9 Mm-2 Mm) Spark Plug Wrench (9 Mm-2 Tillbehör/Accessory Mm) Bygel Clamp Kopp Cup Skyddsnät Screen Anslutningsbleck Terminal Oljesticka Oil dipstick Tätning Seal Rör Tube Bussning Bushing Skruv Screw Mutter Nut Låsnål Cotter Pin Cotter pin Låsring Retainer Stop switch Stop switch Tändstiftsskydd Spark plug elbow Skruv Screw Skruv Screw Drev Gear Länk Link Balanseringsvikt Counterweight Kolvsprint Piston Pin Skruv Screw Tätning Seal Oljesticka kpl Oil filler group Ventilsäte Valve seat Ventilsäte Valve seat Ventilstyrning-insug Valve guide-intake Copyright 204 Global Garden Products STIGA Season 990

13 Utga va Issue Cylinder Cylinder Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Ventilstyrning-utblås Valve guide-exhaust Packning Gasket Isolator Insulator Fläkt Fan Fläkthållare Fan retainer Distans Spacer Excenter Eccentric Stift Pin Copyright 204 Global Garden Products 3 STIGA Season 990

15 Utga va Issue Transaxle Transaxle Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Transaxle assy Transaxle assy Trac 2-TRM Transaxel kpl Transaxle assy Park 2002 P A Hus Case 2 P Drev Gear 5T 2 P Drev Gear 2T 3 P A Drev Gear 20T 4 P A Drev Gear 25T 5 P Gear Gear 3T 5 P A Drev Gear 30T 6 P A Drev Gear 20T 6 P Gear Gear 9T 7 P A Drev Gear 25T 8 P A Drev Gear 30T 9 P A Drev Gear 22T 0 P A Drev Gear 28T P A Drev Gear 37T 2 P Gear Gear 42T 2 P A Drev Gear 42T 3 P Hylsa Collar 4 P Kedjehjul Sprocket 8T 4 P Sprocket Sprocket 4T 5 P Kedjehjul Sprocket 9T 5 P Sprocket Sprocket 0T 6 P Axel Shaft 6 P Axel Shaft 7 P Bevel pinion Bevel pinion 7 P A Drev Bevel pinion 8 P Distans Spacer 9 P Drev Pinion 20 P Drev Gear 2 P Bromsskiva Brake Disc 22 2 P A Kil Key 23 P Hylsa Sleeve 25 P Låsring Reataining ring 26 3 P A Bussning Bushing 27 P A Bussning Bushing 27 2 P A Bussning Bushing 28 P Kedja Chain 28 P A Kedja Chain 29 4 P Bricka Washer 30 2 P Nållager Needle Bearing 30 2 P Needle Bearing Needle Bearing 3 P Kula Ball 32 P Bricka Washer 33 P Skruv Screw 34 P Fjäder Spring 35 7 P Skruv Screw 36 5 P Bricka Washer 37 P Nållager Needle Bearing Copyright 204 Global Garden Products 5 STIGA Season 990

17 Utga va Issue Transaxle Transaxle Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes 37 P Needle Bearing Needle Bearing 38 P Bricka Washer 39 2 P Kullager Ball Bearing 4 2 P Ring Seal 42 P Ring Ring 42 P O-ring O-ring 43 2 P Nållager Needle Bearing 44 P Bricka Washer 46 2 P Ring Ring 47 P Cover Cover 47 P A Lock Cover 48 P Växelförare Shift rod 49 P Axel Shaft 49 P Axel Shaft 50 P A Axel Shaft 50 P A Axel Shaft 5 P Tryck platta Brake plate 52 2 P Bromsbelägg Brake pad 53 2 P TryckSprint Dowel pin 54 P Mutter Nut 55 P Bricka Washer 56 P Bromsarm Brake Lever 56 P Bromsarm Brake Lever 57 2 P Skruv Screw 58 P Hållare Holder 59 P A Drev kpl Gear assy 60 P Bussning Bushing 60 2 P Bussning Bushing 6 2 P Bevel gear Bevel gear 6 2 P Drev Bevel gear 62 2 P Drev Gear 62 2 P Gear Gear 63 P Stift Drive pin 64 2 P Bricka Washer 65 2 P Låsring Snap ring 66 P Stift Pin 67 2 P Bricka Washer 68 P Axel Axle 382 mm 68 P A Axel Axle 368 mm 69 P Axel Axle 335 mm 69 P A Axel Axle 320 mm 70 P Låsring Retaining ring 7 P Plug Plug 72 P Fäste Bracket 77 2 P Bricka Washer 77 2 P Låsring Snap ring Copyright 204 Global Garden Products 7 STIGA Season 990

19 Utga va Issue Ram Frame Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Motorlucka5-0 Engine Cover (Black) Motorhuv -00 Engine Hood Popnit Tap/D/Bs 46 Gf9.5 Pop Rivet Knopp Knob Gummistropp (3 St) Rubber Strap (3 Pcs) Bricka Washer Skruv Screw Mutter Nut Skruv Screw Smörjkopp Kort Rak Grease Dispenser Midjegaffel M Ledaxel 5-0 H-0 Clevis Ledaxelstopp Pivot Shaft Stop Spännstift Locating Pin Skruv Screw Skruv Screw Stödplåt Support Plate Skruv Screw Skruv Screw Instrumentpanel Instrument panel Framskärm Höger-00 Mudguard,Rh (Yellow) Framskärm Vänster-00 Mudguard,Lh (Yellow) Skruv Screw Fjäder Spring Skruv Screw Bricka Washer Centrumaxel Centre Shaft Ledlager Ge7Es Bearing Spännstift Locating Pin Framaxeltapp Front Axle Bricka Washer Värmeisol.matta Heat insulation Sitskonsol-gul Seat Bracket-Yellow Huvstöd Par Engine Cover Support Durkmatta Park Floor Mat Frontdekor Front Trim Plate Däck Tyre Däck Tyre Ventil Valve Assy Bussning Bearing Fälg kpl Rim assy Spring Pin Spring Pin Bricka Washer SaxSprint 4X30 Fz Split Pin Bricka Washer Skruv Screw Mutter Låsmutter Nut Dekalsats Label Kit Copyright 204 Global Garden Products 9 STIGA Season 990

21 Utga va Issue Engine - Brake System Engine - Brake System Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Skruv Screw Skruv Screw Kil Key Mutter Nut Packning Gasket Avgasrör Exhaust Pipe Distans Spacer Låsbleck Lock Skruv Screw Värmeskydd (5-0 F2)20 Heat Protection Skruv Screw Skruv Screw Ljuddämpare Silencer Klämma F Ljuddämp D35 Rid Clamp Mutter Nut Oljeavtappningsrör Kpl. Oil Drain Pipe O-Ring,3 X 2,4 O-ring Plugg Plug Packning Gasket Protection Strip Tanklock Petrol Cap Slangklämma Clamp Kantskyddslist Protection Strip Fäste Bracket Skruv Screw Pedalgummi Pedal Rubber Bromspedal (hö sida) Brake pedal (R. H.) Lager (4 St) Bearing Gasreglage Throttle Cable Knopp Knob Skruv Screw Skruv Screw Skruv Screw Spärr Stop Stag F Parkeringsbroms Stay Nit Kn 5X2 Rivet Starlockbricka Starlock Motorbromswire Cable, Thread Engine Brake Fjäder Spring Fjäder Spring Bromsstopp Brake Stop Skruv Screw Bränsleslang Petrol tube Insats För Ljuddämpare Pipe-Silencer Ljuddämparklämma Clamp Mutter Nut Fjäder Brake Spring Copyright 204 Global Garden Products 2 STIGA Season 990

23 Utga va Issue Power Take-Off Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Mutter Nut Bricka Washer Låshake Locking Pawl Bricka Washer Fjäder Brake Spring Nit Kn 5X2 Rivet Starlockbricka Starlock Reglagespak Control Lever Wire (Kraft) Cable Urkopplingsspak Disengaging Lever Bricka Washer Knopp Knob Reglagestång Control Rod Starlock Starlock T-Handtag Handle Gear Shifter Skruv Screw Fjäder Spring Distans Spacer Fjäder Spring Spännarm Kpl Tensioning Arm Skruv Screw Distans Spacer Spännrulle (Svart) Tension Roller (Black) Mutter Nut Motorremskiva Engine Pulley Skruv Screw Skruv Screw Bricka Washer Distans Spacer Remskiva Belt Pulley Spårring Sgh 40 Circlip Distans Spacer Kullager Ball Bearing Centrumaxel Centre Shaft Bricka Washer Bricka Washer Skruv Screw Spännhjulsarm Tensioning Wheel Arm Distans Spacer Spännhjul Kpl Tension Roller Kullager Ball Bearing Spårring Sgh 40 Circlip Fjäder Spring Bricka Washer Skruv Screw Fjäder Tensioning Wheel Spring Skruv Screw Kilrem V-Belt = Kilrem V-Belt = Copyright 204 Global Garden Products 23 STIGA Season 990

25 Utga va Issue Power Take-Off Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Fingerskydd Guard Tyskland Mutter Strålkastare Nut Working lamp Tyskland Skruv Screw Tyskland Mutter Nut Bussning Bushing Skruv Screw Copyright 204 Global Garden Products 25 STIGA Season 990

26 Utga va Issue Pos. Fig. Antal Q.ty Transmission Art nr Part No Bena mning Ho Skruv Sc Skruv Sc Skruv Sc Mutter Nu Skruv Sc Remstyrning Be Spårring Sga 6 Cir Remskiva Be Skruv Sc Mutter Nu Spännrulle (Svart) Ten Distans Sp Kilrem V-B Motorremskiva En Spännarm Ten Fjäder Sp Skruv Sc Rembygel Be Skruv Sc Skruv Sc Bricka Wa Mutter Nu Växelarm Ge Vinkellänk As8 Din 7802M5 Elb Remstyrning Be Skruv Sc Kopplingswire Clu Växelwire Ge Skruv Sc Transaxel kpl Tra Däck Tyr Däck Tyr Däck Tyr Ventil Val Kil Ke Fälg-bak Rim Skruv Sc Mutter Nu Kablage Bunband Buntband Ca Knopp Kn Bromspedal (vä sida) Bra Lager (4 St) Be Bricka Wa Växelspak Kpl. 48 Ge Växelspakskonsol5-0 Ge Underläggsbleck Cla Fästbygel Att Skruv Sc Copyright 204 Global Garden Products 26 STIGA Season 990 Tra De

27 nsmission Utga va Issue Transmission Transmission scription Pos. Fig. Antal Anma rkning Art nr Q.tyNotes Part No Bena mning Description Anma rkning Notes rew 55 2 L = 50 mm Nit Kn 5X2 Rivet rew rew t rew lt Guide clip lt Pulley ew t Starlockbricka Fjäder Skruv Distans Kil Växelwirefäste Bricka Pedalgummi röduceringsnippel Starlock Spring Screw Spacer Key Clamp Washer Pedal Rubber Nipple Frankrike (F) sion Roller (Black) Fäste Bracket acer elt = Skruv Screw gine Pulley sion Arm ring rew lt Stirrup rew rew sher t ar Shifter Arm ow Link lt Guide ew tch Cable ar Shifter Cable(I=333 ew nsaxle assy e Frankrike (F) e e ve Assy. y -rear rew t ble harness Cable Cable lder ob ke pedal (L. H.) aring sher ar Lever ar Shifter Bracket mp Plate aching Clamp ew Copyright 204 Global Garden Products 27 STIGA Season 990

29 Utga va Issue Elsystem Electrical System Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Strålkastare Kpl Headlamp Assy Glödlampa 2336H3 2 Glow Lamp Skruv Screw Skruv Screw Bricka Washer Elkabel Cable Brytare Switch Tändningslås Kpl Service Starter Switch Assy Tändningsnyckel Ignition Key Brytare Switch Fl.Stift 3868 F/45Msblk Cable Connection Kabel Wire Skruv Screw Kablage Bunband Buntband Cable harness Cable Cable Holder Kabelhärva Cable Harness Låsbleck Clamp Skruv Screw Kabel Cable Skruv Screw Säkringshållare Fuse Box Säkring 8A Fuse 8A Kabel Cable Batterikabel (-) Battery Cable (-) Batterikabel (+) Battery Cable (+) Batteri Battery Batteriunderlägg Battery Pad Batterihållare Battery Holder Kabelgenomföring O 26 Cable Protector Flatst.Hylsa A2507 Flh- Cable Connection Mutter Nut Batteriskydd Guard Cap (+) Batterisyra Battery Acid 2 x 0.85 liter Solenoid Kpl Service Solenoid Stift Cable Connection Mutter Nut Skyddshätta Guard Cap Copyright 204 Global Garden Products 29 STIGA Season 990

31 Utga va Issue Styrning Steering Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Linhjul Steering Pulley Sats 2 st/kit of Linhjul Steering Pulley Bussning Bushing Fäste Bracket Skruv Screw Mutter Nut Bricka Washer Kedjehjul Sprocket Bussning Bushing Skruv Screw Skruv Screw Mutter Nut Kedja79 Länkar Chain W/O Lock Kedjelås Chain Lock Styrwire Steering Cable Left L = 939 mm Styrwire Steering Cable,Rh L = 990 mm Fjäder Spring Fjäder Spring Bricka Washer Mutter Låsmutter Nut Ratt Steering Wheel Ratt Steering Wheel Spännstift Locating Pin Bricka Washer.0 mm Bricka Washer 0.5 mm Rattrör Nedre Steering Column,Lower Lager Bearing Skruv Screw Rattstång Steering Rod Distans Spacer Copyright 204 Global Garden Products 3 STIGA Season 990

33 Utga va Issue Seat Seat Pos. Fig. Antal Q.ty Art nr Part No Bena mning Description Anma rkning Notes Sits Suburban Sa 034 Seat Sitsadapter Seat Adapter Skruv Screw Skruv Screw Skruv Screw Låsbricka Starlock Sitsfäste Kpl Seat Attachment-R.H Sitsfäste Kpl Seat Attachment-L.H Bricka Washer Knopp Knob Fjäder Spring Sitsstång Seat Rod Parallellstag5-0 F24 Tie Bar Mutter Nut Sitsfjäder Seat spring Rör Tube Axel Axle Reglagestång Control Rod Starlock Starlock Spännstång Kpl. Rod Distans Spacer Sits Adjustable seat park Tillbehör/Accessory Mutter Nut Bricka Washer Låsbricka Starlock Sitsfäste Hö Seat Attachment Right Sitsfäste-vä Seat attachment-l.h Axel Shaft Starlock Lock washer Mellanstag Shaft Copyright 204 Global Garden Products 33 STIGA Season 990

34 code pos. q.ty page p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p. 23 Copyright 204 Global Garden Products 34 STIGA -

35 code pos. q.ty page p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p. 9 Copyright 204 Global Garden Products 35 STIGA -

36 code pos. q.ty page p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p p. 9 P p. 7 P p. 7 P p. 7 P p. 7 P p. 5 P p. 5 P p. 7 P p. 7 P p. 7 P p. 5 P p. 5 P p. 5 P p. 5 P p. 5 P p. 5 P p. 5 P p. 5 P p. 7 P p. 7 P p. 7 P p. 7 P p. 7 P p. 7 P p. 5 P p. 5 P p. 5 P p. 5 P p. 5 P p. 7 P p. 7 P p. 7 P p. 7 P p. 7 P p. 7 P p. 5 P p. 5 P p. 7 P p. 7 P p. 7 P p. 5 P p. 5 P p. 5 P p. 5 P p. 5 P p. 5 P p. 5 P p. 7 P p. 5 P p. 7 P p. 7 P p. 7 P p. 5 P p. 7 P p. 7 P p. 7 P p. 7 P p. 7 P p. 7 P p. 7 P p. 7 P p. 5 P p. 7 P p. 7 P p. 7 P p. 7 P p. 5 P p. 5 P p. 5 P p. 7 P p. 7 P A p. 5 P A 47 p. 7 P A 68 p. 7 P A 69 p. 7 P A 50 p. 7 P A 50 p. 7 P A 59 p. 7 P A 7 p. 5 P A 6 p. 5 P A 9 p. 5 P A 7 p. 5 P A 8 p. 5 P A 3 p. 5 P A 4 p. 5 P A 0 p. 5 P A 5 p. 5 P A 2 p. 5 P A p. 5 P A 26 3 p. 5 P A 27 p. 5 P A 27 2 p. 5 P A 28 p. 5 P A 22 2 p. 5 Copyright 204 Global Garden Products 36 STIGA -